施工现场标准化管理实施方案

青岛土木建工集团有限公司施工现场标准化管理实施方案薛家岛办事处烟台前社区安置区高层工程三标段施工现场标准化管理实施方案批准：审核：编制：青岛土木建工集团有限公司二Ｏ一Ｏ年六月施工方案审核表鲁JJ—004□0□0□1工程名称薛家岛办事处烟台前社区安置区高层工程三标段日期2010年6月5日现报上下表中的技术管理文件，请予以审核。类别编制人审核人册数页数施工组织设计////施工方案韩传忠申报简述：我项目部已完成薛家岛办事处烟台前社区安置区高层工程三标段的施工现场标准化管理实施方案的编制，现报上，请予以审批。申报部门（分包单位或项目部）：青岛土木建工集团公司烟台前工程项目部2010年6月5日总承包单位审核意见：有无附页总承包单位名称：青岛土木建工集团有限公司审核人：审核日期：年月日监理单位（建设单位）审批意见：审批结论：同意修改后报重新编制审批部门（单位）：青岛泰鼎工程管理有限公司审批人：审批日期：年月日注：附施工方案山东省建设工程质量监督总站监制工程技术文件报审表鲁JL-001工程名称薛家岛办事处烟台前社区安置区高层工程三标段日期2010年6月5日致：青岛泰鼎工程管理有限公司（监理单位）现报上关于薛家岛办事处烟台前社区安置区高层工程三标段工程技术文件，请予以审定。序号类别编制人册数页数1施工现场标准化管理实施方案韩传忠52编制单位名称：青岛土木建工集团有限公司烟台前项目经理部技术负责人（签字）：申报人（签字）：施工单位审核意见：□有/□无附页施工单位名称：青岛土木建工集团有限公司审核人（签字）：审核日期：年月日监理单位审核意见：审定结论：□同意□修改后再报□重新编制监理单位名称：青岛泰鼎工程管理有限公司总监理工程师（签字）日期年月日001施工方案审批表LJA3—1—1工程名称薛家岛办事处烟台前社区安置区高层工程三标段工程地点金沙滩路以北、船厂路以南、南洋学院以西建设单位青岛市黄岛区薛家岛街道办事处烟台前社区居民委员会建筑面积32059.5M2）结构类型框架-剪力墙结构工程造价5543.5（万元）设计单位青岛建筑设计研究院有限公司监理单位青岛泰鼎工程管理有限公司层数、高度20F-24F建筑物跨度（M）开、竣工日期2010年5月16日至2011年11月15日编制人项目负责人吴明杰项目安全负责人栾世峰参加会审人员签字单位职务职称签名施工单位审批结论技术负责人：（签字盖章）年月日监理单位审批结论总监理工程师：（签字盖章）年月日设单位审批结论项目经理：（签字盖章）年月日目录1工程概况······························72现场平面布置····························72.1围墙及大门·················································································72.2临设··························································································72.3洗车槽·······················································································72.4垃圾堆放····················································································72.5现场道路····················································································72.6场容场貌····················································································73安全管理······························73.1开工准备····················································································83.2安全检查····················································································83.3安全事故处理··············································································83.4安全防护措施··············································································83.5季节性安全措施··········································································104质量管理····························114.1质量方针···················································································114.2质量控制体系·············································································114.3质量职责···················································································114.4质量保证体系·············································································124.5质量保证措施·············································································125文明管理····························135.1安全文明教育·············································································135.2现场安全警示·············································································135.3防火管理···················································································135.4防尘管理···················································································146信息化管理····························147分包管理·····························147.1劳务分包管理·············································································147.2专业分包管理·············································································148综合治理·····························141工程概况青岛土木建工集团有限公司薛家岛烟台前社区安置区高层工程三标段工程，建筑地点位于开发区金沙滩路以北、船厂路以南、南洋学院以西。建筑总面积为32059.5㎡，建筑层数20F-24F，本工程为框剪结构，有人防地下车库。一级建筑防火为一类，建筑耐火等级一级，人防工程类别和防护等级核六级。防水等级二级，抗震防设烈度六度。为提高本项目部施工现场管理水平，促进本施工现场管理科学化、规范化和系统化，特制定本方案。2现场平面布置2.1围墙及大门本工程采用2.4米高彩钢板对施工场地进行围蔽，施工现场大门宽度为10m。2.2临设由于本工程场地比较狭窄，办公区设于2#楼东侧，生活区设于3#、4#楼北侧；现场设置仓库、加工棚、守卫室等，各功能区位置祥见施工总平面布置图2.3洗车槽为确保出入工地的车辆不把工地泥土的带出工地而污染市容或影响小区的环境卫生，在工地正门出入口处设置洗车槽，凡出入工地的车辆必须先冲洗干净轮子方允许开出工地大门。2.4垃圾堆放工地在宿舍区、办公区分别设置垃圾箱，作为生活垃圾和不能回收利用的施工垃圾投放场地，每天安排清洁工人及时清理并运走。2.5现场道路场区留设1号门、2号门，与场外市政道路连接。场区施工用临时道路主道为连通1号大门混凝土道，道宽10m，300mm厚石渣垫层、C20混凝土120mm厚随打随抹；2号大门为人员、车辆的出入通道，布置在4#楼的北侧，道路宽6m，东向4m,300m厚碎石垫层、C20混凝土120mm厚随打随抹。材料堆场和加工场均与临时道路用混凝土道路连通。场区施工用临时道路主道采用水泥硬化，其主要目的是降尘及预防雨天进出现场车辆车轮带泥污染市政道路，以达到城市管理需要。2.6场容场貌2.6.1施工现场大门处设置门卫，实行人员登记严禁无关人员进入施工现场。2.6.2大门处设置十牌两图，即施工标志牌、安全措施牌、文明施工牌、入场须知牌、消防保卫牌、管理人员名单及监督电话牌、建筑工人维权须知牌、企业标志牌等和施工现场平面布置图、工程立体效果图，材质为不锈钢，设置牢固美观并量化。所有材料按类存放，整齐有序，并设置标示牌。2.6.3施工现场为避免扬尘污染进行封闭作业，运输、装卸采用遮盖、洒水等措施。3安全管理3.1开工准备工程开工前先为职工办理保险，并办理报监手续。会同建设单位、监理单位对周边环境进行评估。对安全文明施工费用专款专用，施工现场严格执行安全生产标准规范规定，制定各工种安全操作规程。安全操作规程列为日常安全活动和安全教育技术主要内容。3.2安全检查3.2.1本项目每天由专职安全员、兼职安全员对工地现场的安全文明生产工作进行巡查，专职安全员做总体巡查，检查情况填入质安日志，兼职安全员负责班前班后对责任区域巡查，及时发现问题及时解决。3.2.2每月由项目经理组织项目部对照JGJ59-99标准进行安全文明施工自检，对各班组的作业情况进行评比打分，对重大隐患开出限期整改通知单，对违章现象进行制止和处罚，对安全文明生产先进班组给予奖励。3.2.3公司每季度定期组织一次安全文明施工大检查，平时进行季节性检查和节假日前后安全检查等不定期检查。项目部将认真对照公司检查所提出存在问题组织整改。3.2.4施工过程中，根据需要由专业人员进行专业检查，如电工对临时用电的巡视、对电箱或用电设备对地电阻的摇测检查等。3.2.5检查结果及整改措施1项目部每次自检均将检查结果公布，并将隐患按“三定”（即定人、定期限、定措施）落实整改。2到了整改期限，由专职安全员组织复查，对未按期完成的进行处罚。3.3安全事故处理3.3.1采取多项措施以预防减少工伤事故的发生，若不幸发生了工伤事故，则将采取紧急措施防止事故的扩大：抢救伤员、保护现场、逐级上报，调查事故（包括向当事人、目击证人做笔录、拍照等）等。由项目经理牵头对事故进行调查处理（一般轻伤事故）或配合公司调查组的工作（重伤以上事故）。3.3.2通知对事故的调查，查明事故的经过、原因、责任等情况，按四不放过（即事故原因未调查清楚不放过，事故责任者和周围群众未受