DB11T 636-2023 施工现场施工升降机检验技术规程

北京市地方标准编号：DB11/T636-2023施工现场施工升降机检验技术规程Technicalregulationforinspectionofbuildershoistsonconstructionsite2023-12-27发布2024-04-01实施北京市住房和城乡建设委员会北京市市场监督管理局联合发布DB编号：DB11/T636-2023主编单位：国家建筑城建机械质量监督检验中心北京建筑大学批准部门：北京市市场监督管理局施行日期：2024年04月01日2023北京前言根据北京市市场监督管理局《2020年北京市地方标准制修订项目计划》（京市监发﹝2020﹞19号）的要求，规程编制组经广泛调查研究，认真总结实践经验，参考国内相关标准，并在广泛征求意见的基础上，修订本规程。本规程的主要技术内容是：1总则；2检验的必备条件；3检验内容；4检验工作要求；5判定规则。本规程修订的主要技术内容是：1增加了对检验现场环境及温度、电压等规定；2增加了施工升降机任何部分与架空输电线的安全距离等作业环境的要求；3增加了非常规基础和非常规附墙架的解决方案；4增加了安全钩、减速开关、急停开关、缓冲器、超载检测装置等安全装置的要求；5增加了施工升降机不应使用非原厂生产的主要受力结构件的要求；6增加了安装用附件及对重的要求；7增加了滑触线供电的要求；8增加了自动控制施工升降机的要求；9增加了新出厂首次安装的施工升降机检验要求；10增加了静载荷试验、动载荷试验、稳定性试验和超载检测装置试验；11对产品铭牌包括的内容、地面围栏高度、结构件连接等要求进行了修订；12主回路、控制回路、电气设备的相间绝缘电阻修改为不应小于1.0MΩ等。本规程由北京市住房和城乡建设委员会和北京市市场监督管理局负责管理，北京市住房和城乡建设委员会归口并组织实施，由国家建筑城建机械质量监督检验中心负责具体技术内容解释，执行过程中如有意见和建议，请寄送国家建筑城建机械质量监督检验中心（地址：北京市丰台区方庄紫芳园六区1号楼底商2-213室，邮编：100078，电话：[phone]）。本规程主编单位：国家建筑城建机械质量监督检验中心北京建筑大学本规程参编单位：北京市建设工程安全质量监督总站北京市建设机械与材料质量监督检验站有限公司北京市建筑机械行业协会北京市特种设备检验检测研究院中国新兴建筑工程有限责任公司中联重科股份有限公司北京宏升卓越工程机械有限公司中铁建设集团北京工程有限公司中国新兴建设开发有限责任公司北京市大兴区建设集团有限公司北京市市政六建设工程有限公司中建一局集团第三建筑有限公司中建二局第三建筑工程有限公司本规程主要起草人员：徐晓龙谢贻东魏吉祥赵光耀凌振军朝泽东杨杰周金刚魏巍王洪燕李宗亮杨建伟王湘龙邵俊武宋志光赵国安卢宁刘海华刘生国王军刘耀飞安戈韩晓晨高著海李广文刘晓婷郭玉增孙志盛本规程主要审查人员：赵伯锐李守林陶天华田志成王珏孙艳秋宋光明目次1总则···········································································12检验的必备条件····························································23检验内容·····································································33.1技术资料·······························································33.2作业环境·······························································33.3标志·····································································43.4基础和围栏····························································43.5吊笼·····································································53.6安全装置·······························································63.7结构、连接件及安装用附件·······································83.8传动系统·······························································83.9对重·····································································93.10导向·································································103.11安装垂直度偏差··················································103.12电气系统···························································113.13层门·································································123.14防护棚······························································123.15自动控制施工升降机的专项要求·····························123.16试验·································································134检验工作要求·····························································155判定规则···································································17附录A检验使用的仪器设备·············································18附录B齿轮齿条式施工升降机检验报告······························19附录C钢丝绳式施工升降机检验报告·································30附录D施工现场施工升降机检验意见通知书························38本标准用词说明·······························································39引用标准名录··································································40条文说明········································································41·························································12Basicrequirements·························································23Contents······································································33.1Technicaldata·························································33.2Operatingenvironment···············································33.3Plates···································································43.4Foundationandguardrail············································43.5Cage····································································53.6Safetydevices·························································63.7Structuresandjointsandinstallationaccessories·················83.8Drivingsystem························································83.9Counterweight·························································93.10Guidingdevices····················································103.11Deviationofperpendicularityformast·························103.12Electricalsystems·················································113.13Landinggates······················································123.14Headguardshed···················································123.15Specialrequirementsforautomaticcontrolbuildershoist···123.16Test··································································134Requirementsofinspection············································155Rulesofinspection·······················································17AppendixAInspectionequipments·····································18AppendixBInspectionrepor